Page 1 of 3

X Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
   Follow-Up
    Possible FBI
    Complaint
   Other
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
ITEM
X
WT
DESCRIPTION
 
FOOD
18
 
1
 Pre-flushed, scraped, soaked
34
  
1
 Outside storage area, enclosures properly constructed, clean: controlled incineration
*1
  
5
 Source, Wholesome, No Spoilage
19
  
2
 Wash, rinse after: clean, proper temperature
2
  
1
 Original Container, Properly Labeled
*20
  
4
 Sanitization rinse: Clean, temperature, concentration   INSECT, RODENT ANIMAL CONTROL
 
FOOD PROTECTION
*35
  
4
 Presence of insects/rodents - outer openings protected; no birds, turtles, or other animals
*3
  
5
 Potentially hazardous food meets temperature requirements during storage, preparation, display, service and transportation
21
X
1
 Wiping cloths: clean, use restricted
22
X
2
 Food contact surfaces of equipment and utensils clean, free of abrasives and detergents  
FLOORS WALLS AND CEILINGS
36
X
1
 Floor: constructed, drained, clean, good repair, covering installation, dustless cleaning methods
*4
  
4
 Facilities to maintain product temperature
23
X
1
 Non-food contact surfaces of equipment and utensils clean
5
 
1
 Thermometers provided and conspicuous
37
X
1
 Walls, ceiling, attached equipment: constructed good repair, clean surfaces, dustless cleaning methods
6
X
2
 Potentially hazardous food properly thawed
24
  
1
 Storage, handling of clean equipment utensils
*7
  
4
 Unwrapped and potentially hazardous food not re-served, Cross Contamination
25
X
1
 Single-service articles, storage, dispensing  
LIGHTING
26
  
2
 No re-use of single-service articles
38
  
1
 Lighting provided as required - Fixtures shielded
8
  
2
 Food protection during storage, preparation, display, service and transportation  
WATER
  
VENTILATION
*27
 
5
 Water source, safe: Hot and cold under pressure
39
  
1
 Rooms and equipment - vented as required
9
  
2
 Handling of food(ice) minimized, methods  
SEWAGE
  
DRESSING ROOMS
10
  
1
 Food(ice) dispensing utensils properly stored
*28
  
4
 Sewage and waste water disposal
40
  
1
 Rooms clean, lockers provided, facilities clean
 
PERSONNEL
  
PLUMBING
  
OTHER OPERATIONS
*11
  
5
 Personnel with infections restricted
29
  
1
 Installed, maintained
*41
X
5
 Toxic items properly stored, labeled and used
*12
  
5
 Hands washed and clean, good hygienic practices
*30
 
5
 Cross-connection, back siphonage-backflow
42
  
1
 Premises: maintained, free of litter, unnecessary articles, cleaning/maintenance equipment properly stored, authorized personnel
13
  
1
Clean clothes, hair restraints
  
TOILET AND HAND-WASHING FACILITIES
 
FOOD EQUIPMENT AND UTENSILS
14
  
2
 Food (ice) contact surfaces: designed, constructed, maintained, installed, located
*31
  
4
 Number, convenient, accessible, designed, installed
43
  
1
 Complete separation from living/sleeping quarters, laundry
32
 
2
 Toilet rooms enclosed, self-closing doors, fixtures, good repair, clean: Hand cleanser, sanitary towels/hand drying devices provided. Proper waste receptacles, tissue
15
X
1
 Non-food (ice) contact surfaces: designed, constructed, maintained, installed, located.
44
  
1
 Clean, soiled linen properly stored
 
CERTIFIED PERSONNEL
16
  
2
 Dishwashing facilities: designed, constructed, maintained, installed, located, operated
*45
     Management personnel certified Yes X No     Registered for class    
 
GARBAGE AND REFUSE DIPSOSAL
17
  
1
 Accurate thermometers, chemical test kits provided, gauge cook
33
  
2
 Containers or receptacles covered: adequate number, insect/rodent proof, frequency, clean
 
      
Sanitizer Requirement:  Chemical   >200 ppm                   Dishwasher Temperature   200ppm °F or label
Food Temperatures:   cheese 41, skillet 146, chicken 41, bacon 264, soup 141, gravy 140, beef 41, gravy 142, ham 36, steak 37, soup 169, cole slaw 31, ice cream -2
 
General Comments
No follow up is needed at this time
HACCP: Please keep eggs inside coolers when cooking if really busy a sleeve can be kept out but not more than one. Please start using the hand sink in the bar set up with soap and paper towels. 
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  05/29/2008 Time In  9:30 AM Time Out  10:40 AM Sanitation Score  85 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  90  
 
Page 2 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
*41  Observed all sanitizer buckets to be too strong *Provide for the sanitizer solution to be no stronger than the required concentration (750.820) Dumped all buckets and remixed solution Immediate/Onsite
6  Observed beef to be improperly thawed Provide for all potentially hazardous foods to be properly thawed in one of the following ways: 1) In a refrigerator unit in a way that the temperature doe not exceed 41°F 2) Under potable running water at a temperature of 70°F or below 3) In a microwave oven only when it is a part of the cooking process 4) As a part of the conventional cooking process (750.240) Next Inspection
15  Observed the following improper non-food contact surfaces: 1. metal broken on 3 bay faucet 2. remove cardboard from under mats 3. remove cardboard from under flour etc. 4. torn gasket on prep cooler *Please repair replace (750.690) Next Inspection
21  Observed wiping cloth(s) to be improperly stored: *Provide for all wiping cloths to be stored completely submerged in an approved sanitizer solution while not being used (750.810) Next Inspection
22  Observed the inside of the microwave and some skillet plates to be in need of cleaning *Please clean (750.800) Next Inspection
23  Observed the following non-food contact surfaces to be in need of cleaning: 1. pop in box lines and grey plastic pieces 2. inside all coolers/freezers and gaskets 3. inside friar cabinets 4. outside large white buckets 5. radio 6. hand sink handles 7. shelves with hot sauce *Please clean (750.800) Next Inspection
25  Observed the toothpicks to be improperly stored: *Provide for all single service articles to be stored inverted with tassels up and out (750.880) Next Inspection
36  Observed floors in cooking area to be in need of cleaning esp. under equipment *Please clean (750.1220) Observed floor behind bar to be worn and in need of replacing *Please repair (750.1200) Next Inspection
37  Observed walls behind equipment to be in need of cleaning *Please clean (750.1220) Next Inspection
     
     
     
     
     
     
     
     
     
     
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  05/29/2008 Time In  9:30 AM Time Out  10:40 AM Sanitation Score  85 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  90  
 
Page 3 of 3

    Food Service Establishment
    Retail Food Store
    Temporary
    Mobile
KANKAKEE COUNTY HEALTH DEPARTMENT
DIVISION OF ENVIRONMENTAL HEALTH
2390 W. STATION STREET
KANKAKEE, IL 60901
(815) 802-9410, (815) 802-9411 (FAX)

FOOD SERVICE SANITARY INSPECTION REPORT
 Establishment #   MA031  
    Pre-opening
X Original Inspection
    Reinspection
    Follow-Up__________
    Possible FBI
    Complaint
    Other______________
Name of Establishment  MAYBERRY JUNCTION RESTAURANT Address  390 N LOCUST
Owner or Operator   KIOUSIS, ARLEEN City   MANTENO Zip Code   60950
 

ITEM
Remarks and Recommendations for Corrections
Corrected By
     
Report and Instructions Received By   /  
 
(Please Print)
  
(Signature of Owner or Representative)
Date  05/29/2008 Time In  9:30 AM Time Out  10:40 AM Sanitation Score  85 (100 Minus Demerits)
By  Janet Weldon (Sanitarian) Adjusted Score  90